Toyota Avalon Service & Repair Manual: Brake Actuator Operation Sound is Loud during Initial Check

CAUTION / NOTICE / HINT

NOTICE:

When replacing the skid control ECU (brake actuator assembly), perform system variant learning and acceleration sensor zero point calibration.

Click here

PROCEDURE

1.

PERFORM ROAD TEST

(a) After turning the engine switch on (IG), compare the operating sound of the brake actuator the first time the vehicle speed reaches 45 km/h (28 mph) with a known good vehicle of the same model.

OK:

The operating sound is the same or quieter than that of a known good vehicle of the same model.

HINT:

When the vehicle speed reaches approximately 40 km/h (25 mph), the initial check of the brake actuator assembly is performed and pump motor operation sounds are generated.

OK

END

NG

2.

CHECK BRAKE ACTUATOR BOLT CUSHION

(a) Check that the cushion of the brake actuator bracket assembly is not worn, damaged or deformed.

OK:

The brake actuator bracket assembly is not worn, damaged or deformed.

NG

REPLACE BRAKE ACTUATOR BOLT CUSHION

OK

3.

ADJUST INSTALLATION OF BRAKE ACTUATOR ASSEMBLY

(a) Drain the brake fluid.

(b) Disconnect all brake lines from the brake actuator assembly.

Click here

(c) Connect each brake line so that the cushion of the brake actuator assembly is tensioned evenly.

Click here

NOTICE:

After connecting all the brake lines, add brake fluid and bleed the brake system.

Click here

HINT:

By reducing the tension on the brake lines and cushion, the operating sound of the brake actuator assembly may be reduced.

(d) Check that no brake lines interfere with the vehicle body or other components.

NEXT

4.

RECHECK SYMPTOM

(a) Perform a road test and check the magnitude of the operating sound again.

OK:

The operating sound is the same or quieter than that of a known good vehicle of the same model.

OK

END

NG

REPLACE BRAKE ACTUATOR ASSEMBLY

    ABS Warning Light Remains ON

    Brake Hold Operated Indicator Light Circuit

    See More:

    Toyota Avalon Service & Repair Manual > Parking Assist Monitor System(for Gasoline Model): Back Camera Disconnected (C1622)
    DESCRIPTION This DTC is stored if the radio and display receiver assembly judges that the signals or signal lines between the television camera assembly, and the radio and display receiver assembly are not normal as a result of its self check. DTC No. Detection Item DTC Detection Condition Trouble A ...

    Toyota Avalon Owners Manual

    Toyota Avalon Service & Repair Manual

    © 2022 Copyright www.tavalon.net
    0.0137